Estimated read time: 2-3 minutes
This archived news story is available only for your personal, non-commercial use. Information in the story may be outdated or superseded by additional information. Reading or replaying the story in its archived form does not constitute a republication of the story.
WASHINGTON (CNN) — An Air Force reconnaissance airplane caught fire in April, endangering the lives of 27 airmen aboard the plane — all because a retaining nut connecting oxygen tubing was not tightened properly, accident investigators have determined. The report blamed a private defense contracting company for the accident.
"Failure by L-3 Communications depot maintenance personnel to tighten a retaining nut connecting a metal oxygen tube to a junction fitting above the galley properly caused an oxygen leak. This leak created a highly flammable oxygen-rich environment that ignited," U.S. Air Force investigators wrote in a report published August 3.
Investigators determined the ensuing fire caused $62.4 millon in damage to the RC-135V, which electronically snoops on adversaries and relays gathered intelligence to commanders.
L-3 Communications spokesman Bruce Rogowski declined comment and referred questions to the Air Force.
The plane, which was about to take off on a training mission from Offutt Air Force Base in Nebraska on April 30, instead skidded to a stop on the runway. All 27 crew members made it off safely, The Omaha World-Herald reported.
The World-Herald first obtained the report through a Freedom of Information Act request.
The Air Force report said the jet hit about 51 mph when the pilot aborted takeoff, well below its takeoff speed.
A former pilot contacted by the World-Herald estimated that had the plane taken off, all 27 crew members could have died in an ensuing crash.
"This event could have easily been that catastrophic, because of the intensity of the fire," Robert Hopkins III told the paper. "Had they taken off, it could easily have been fatal."
This event could have easily been that catastrophic, because of the intensity of the fire. Had they taken off, it could easily have been fatal.
–Robert Hopkins III
The Air Force has 17 RC-135V/Ws in its fleet. One of them was intercepted by a Russian SU-27 jet over the Baltic Sea earlier this year in an incident that drew strong criticism from the Pentagon.
The U.S. crew believed the Russian pilot's actions were "unsafe and unprofessional due to the aggressive maneuvers it performed in close proximity to their aircraft and its high rate of speed," Pentagon spokesman Mark Wright said in April.
That was not the first time the U.S. has complained about an incident involving a RC-135 and a SU-27. A year earlier, a Russian jet flew within 100 feet of a RC-135 over the Sea of Okhotsk in the western Pacific, according to U.S. officials who called it "one of the most dangerous close passes in decades."
Copyright 2015 Cable News Network. Turner Broadcasting System, Inc. All Rights Reserved.